Boiling Water in Clay Soil

When you’re stuck in the middle of no-man’s-land, and boiling is your only choice for disinfecting water, how do you get that job accomplished without a container?

You may already know the trick of rock boiling, which is the technique of using fire-heated stones, dropped into a cavity filled with water. This method is used when your water container cannot be moved (like a cavity in a rock) or should not be placed over the fire (like a wooden bowl or bark vessel). But can you rock boil without any rock cavities or another type of container?

Yes. You can actually boil water in a hole in the ground, and I’ve been trying it in different ways for years.

Through trial and error, I’ve finally found the secret: dig your hole in clay soil. Now I’ve rock boiled in plenty of holes in the dirt, when no other vessel was available or a lack of time prevented my construction of a container. The method is a last ditch effort (no pun intended), to get water that has been boiled to kill pathogens. It always starts out fine, but then boiling bubbles created by the red-hot rocks quickly turn the puddle of muddy water into a puddle of hot mud.

After noticing how hard my clay rich soil became when using Dakota fire holes, my solution was clear: Dig a hole, make the walls smooth with clay and burn a fire in the hole to harden the clay.

After the first rock boiling, I could still drink the water. Sure the water still becomes a muddy mess, but the finished boiled water looks a lot more like water, and a lot less like chocolate pudding. Just burn a hot fire from small sticks in your clay lined hole for 20 minutes. Let the fire die, and scoop out all the charcoal and ash (ash and water make lye, you don’t need that). Then improvise something to carry water from your source to the fired clay hole. Heat some rocks for 40 minutes in a fire, drop them in the hole, and boil away.

Tell us if you have rock boiled, out of curiosity or desperation, in the comments section below.

Similar posts
  • Use Your Clothing To FloatThe first rule in a survival situation is to stay calm at all times. Especially,  if you are thrown overboard from a boat or caught in a flood. Panic can cause death in an instant. Take several minutes to tread water as you calm yourself down and assess the situation. How far away is land? [...]
  • Solar Water DisinfectionLargely advocated for developing countries, solar water disinfection is gaining some traction in the survival skills crowd. Imagine an end to boiling your water in order to make it safe. Consider how nice it would be to no longer need expensive water filtration devices or potentially toxic water-treatment chemicals. Sounds great, right? Too good to [...]
  • Make A Swedish Marshmallow For WaterBeing snowbound is a bit like being stuck in a life raft in the middle of the ocean. In both cases, you’re surrounded by water, but it’s not suitable to drink unless you do something to it first. In the raft, you’d need a solar still or a reverse osmosis filter. But what’s the approach [...]
  • How To Desalinate Water in the Field ...Last week, I received a call from some friends who provide survival training for a branch of the Department of Justice. They were mid-experiment, trying to desalinate water with field expedient gear. Short of building a still as featured on the show Moonshiners, they couldn’t figure out how to achieve the necessary controlled water condensation. [...]
  • A Life With NO Running WaterSomething I have learned over the years is that my own experience coupled with the anecdotal experience of my peers will always trump the theoretical.  Most assuredly, this also applies to coping skills learned in a disaster or what I like to call a “Disruptive Event”. Some of you might recall that due to a [...]

No Comments Yet

Join the discussion...